交聯聚乙烯絕緣電力電纜XLPE INSULATED POWER CABLE一、交聯聚乙爆絕緣電力電纜簡介 Brief introlluction to Xlpe lnsulated Power Cable我國自從六十年代以來，交聯染乙烤電纜得到飛速發展，已經取代了油浸紙絕緣電力電境，交聯電黣，因其具有優異的電氣性能、良好的熱過載特性，電壓等級高，傳輸容量大、重量輕及數設不受落差、可垂直數設，電纜安裝和運行維護方便等優點，它不僅可以在35KV及以下的中，低壓范圍內得到廣泛應用，而且在66.110及220KV的高壓輸電線路中也已大量采用，并且在某些先進工業國家已經開發出了500KV壓交聯電力電纜。Since the 1960s,China has made rapid progress in its XLP'E cable,replacing the oil paper insulated power cable, Because of its outstanding electricityproperty.good overload,high voltage,.large transmission capacity.light weight and laying without drop limit,vertical laying.convenient installation andoperation maintenance and other strong points,XL. cable can not only be widely used in 35KV and below medium and low voltage scope, but also largelyused in 66,110 and 220KV high voltage transmission lines. And, in some developed industrial countries 500KV super-high voltage XL, cables have beenopened up.二、產品標準 Product Standard:我廠按國際GB/T12706-2008《額定電壓1KV到35KV擠包絕緣電力電境及附件），GB11017-89《額定電壓110KV銅芯，鋁芯交聯聚乙烯絕緣電力電纜）生產交聯雜乙烤電埋，GB/T12706-2008標準等效國際標準IEC502-2001《額定電壓1-30KV的擠包絕緣電力電境及附件），GB11017-89參照采用國際標準IEC810-1988（額定電壓：30KV-150KV擠包絕緣電力電纜實驗）。本廠還可以根據用戶要求，設計制造具有某些特殊要求的交聯電纜Our factory produces XLPE cable according to state standard GB/T12706-2008 "Rated voltage 35KV and below copper core and aluminium coreplastic insulated power cable" and GB11017-89 "Rated voltage 110KV copper core and aluminium core XLPE insulated power cable" .The GB/T12706-2008 standard is equivalent to international standard IEC502-2004 "Rated voltage 1-30KV plastic extruded and wrapped insulated power cable.TheGB11017-89 standard adopts intermational standand IEC840-1988 "Rated voltage 30-150K extruded and wrapped insulated power cable experíment" .Our fatory can also design and produce some XL. cable for special requirements according to clients' demand.三、使用性能 Property for Use:1電纜導體的高額定溫度為90℃。2短路時（長持續時間不超過5S)電纜導體的高溫度不超過250℃.1. Max,rated temperature of cable conductor is 90 ℃.2. For short eireuit (max. sustained time not exeeeding is), max.temperature of eable conductor not exceeding 250 ℃.四、交聯電纜額定電壓等級、型號、規格規定 XL cable rated voltage grade,type and specfications:電纜額定電壓的選擇：電纜額定電壓應適于使用電纜的系統電壓和運行狀況，用U./U（Um）表示，單位為KV。U.——電纜設計用的導體或金屬套之間的額定電壓U——電纜設計用的導體之間的頻定工頻電壓。Um——設備高電壓（使用設備的系統高電壓的大值)Cable rated voltage selection: Cable rated voltage should be suitable to the system voltage and operation conditions of used cable,expressed by U'./Ai(U'm), all are effective value, unit is KV.U. -rated voltage between conductor for cable design and sereen or metal sheath.U - rated industrial frequency voltage between conductors for cable design.U'm -max. voltage of equipment (max. value of max. voltage or equipment system used).五、相系統用電纜的額定電壓如表1規定 For rated voltage of system cable,see Table 1.單位 Unit：KV表1Table 1U3610152035631101:303.617.524Uim7.212364272.5126   1類電纜0.68.721183.6612183664Category 1 CableU第2類電纜260.63668.7121848-Category 2 cable注：以.按系統接地故障持續時間不同分為兩類，具體分類如下：1類電纜——用于單相接地故障時間每一次一般不大于lmmin的系統，也用于長不超過8h，年累計不超過125h的系統。第2類電境——用于接地放障時間更長的系統，對電境絕緣性能要求較高的場合，也可采用第2類。Note: L'. is divided into two categories according to different sastained time for system' s earthing breakdowreCategory I- used in sstem with singe phase earthing breakdown genernly les than I min. each timealbo used in les than 8h,an accumul-ation of less than l25h in a year._____.__.______._______.._____..__.Categoty 2- used in system with earthing breakdown more longer, and also used in places with relatively higher demand in cable insulation.